Additional steering facilitates manoeuvring
by BPW
Future Lab
EcoMotion
Success Story
Logistics Hero
BPW’s Best
Select Page
FollowFollowFollowFollowFollowFollowFollow
Search for:
FollowFollowFollowFollowFollowFollowFollow
by BPW
Future Lab
EcoMotion
Success Story
Logistics Hero
BPW’s Best
BPW Active Reverse Control: The axle thinks and steers
February 2021 | BPW’s Best
Reading time: approx. 4 minutesText: Oliver SchönfeldPhotos: Pia Simon
Manoeuvring on narrow farms and their even narrower access roads is an art in itself. With these special requirements in mind, trailer specialist Finkl has developed a new generation of vehicles for animal transport and uses the BPW Active Reverse Control auxiliary steering system. Customers from all over Europe are enthusiastic about the advantages.
The vehicle manufacturers of Josef Finkl KG from Bissingen in Bavaria have been dealing with the special requirements in the development of animal transporters for more than 40 years – and have thus built up a wealth of experience that makes the decisive difference from the customer’s point of view. After all, reliability and durability under demanding operating conditions are particularly important for the special trailers. In addition, numerous country-specific regulations and requirements regarding animal welfare have to be observed. With its strategy of specialisation, Finkl has made a name for itself as a quality supplier throughout Europe.
Durability and reliability are crucial
Since the mid-1980s, the company has relied on solutions from BPW Bergische Achsen KG. “Today, we only use axle systems from BPW,” emphasises Josef Finkl, the company’s third generation owner. “The high quality, the very good service and the ease of repair of the axles confirm us in this decision.” Especially for animal transporters, which are often in use for 15 years or more, durability and reliability are decisive purchase criteria. Josef Finkl explains: “A rule of thumb is that a trailer in this transport segment is used as long as three tractor units. Our Kombi-Liners and Low-Liners have to measure up to these high-quality expectations.”
»Auxiliary steering provides significant relief for the driver.«
Josef Finkl, owner and managing director of Josef Finkl KG
Facilitate manoeuvring when reversing
Steered trailers have been part of Finkl’s vehicle programme for many years. After all, space on farms and their access roads is often so limited that manoeuvring when reversing becomes a challenge every time. “Auxiliary steering offers considerable relief for the driver there,” explains Josef Finkl. In the past, the company has mainly worked with mechanical rod steering systems. Although this makes driving easier, it is still only a compromise – high assembly costs, high weight and a lot of service requirements during operation speak against this conventional solution
BPW Active Reverse Control: Auxiliary steering for safe manoeuvring
This made it all the quicker for Fahrzeugbau Finkl to decide to be one of the first users to work with the new variant of BPW Active Reverse Control (ARC). In addition to the familiar version for standard axles with 22.5″ single tyres, which is also used at Fahrzeugbau Finkl, the auxiliary steering in combination with the self-steering axle will soon also be available for low-loaders with 17.5″ twin tyres with SN 3020 drum brake. With a steering angle of 12 to 18 degrees, or up to 20 degrees for low-loaders, the additional steering makes manoeuvring considerably easier, and that with a particularly compact design. The series introduction of the low-loader version expands the auxiliary steering portfolio up to 12 tonnes axle load.
Better manoeuvrability proves its worth
The ARC has fully met the high expectations at Finkl. The first customers who have opted for the new generation of trailers praise the improved manoeuvrability in narrow access roads and yards and are pleased with the increased efficiency in daily vehicle operation. The compact and at the same time weight-saving design of the additional steering also brings a gain in efficiency. Denmark, for example, prescribes a minimum height of 98 centimetres per floor for animal transporters. “Due to the compact dimensions of the additional steering system compared to a rod steering system, the transport capacity increases significantly,” explains Josef Finkl. The simple installation according to the plug-and-play principle thanks to the factory-prepared axles as well as the pre-set software also convinced the Bavarian vehicle builders. Another advantage: ARC does not require approval. Since the trailers for animal transport have their own batteries, this is used to control the steering system. This makes the energy supply from the tractor unnecessary.
Training for the drivers
The transport companies from Germany, France and the Netherlands, which already have a Finkl trailer with ARC in use, are enthusiastic. The advantages in daily handling speak for themselves. Only the reverse manoeuvring with assistance requires some getting used to, Josef Finkl admits. “If possible, we usually train our customers’ drivers directly on this when they pick up the trailers from us.” But then they quickly get to grips with the additional steering and the remote control. “And afterwards the advantages, from time savings to less tyre wear, speak for themselves.”
Vehicle construction for over 80 years
Passion for vehicle construction has shaped the company development at Finkl for over 80 years. The grandfather of the current owner founded a blacksmith’s and wagon smithy in the market town of Bissingen in 1938. Since 1949, the company has been manufacturing at its current location on the outskirts of Bissingen. Several times over the decades, most recently in 2006, the assembly halls and the paint shop were expanded. Today, 90 highly qualified employees – from vehicle builders to painters and technicians – are employed at the company’s main site. In 2007, a second production facility was added in Roggendorf near Schwerin with currently 45 employees.
Specialisation as a concept for success
After the beginnings with the production of farm wagons and horse transporters, tipping trailers and tipping semi-trailers for the construction industry formed a second mainstay at the end of the 1960s. A particular focus was the production of special vehicles for the extensive construction activities in the run-up to the 1972 Olympic Games in Munich. In the mid-1980s, the company decided to take the next step in specialisation. Since then, the focus has been solely on the development and construction of vehicles for animal transport. “We know our customers’ requirements and find solutions in strict compliance with legislation that places a high value on animal welfare,” emphasises owner Josef Finkl.
Click to rate this post!
[Total: 2 Average: 5]
PreviousVirtual truck racing: racing drivers also work from home
Next“My drivers have a big share in the company’s success”
PLEASE ALSO READ
upBox: the digital and automated spare parts warehouse
March 2021
Virtual truck racing: racing drivers also work from home
February 2021
From the idea to real innovation
February 2021
Submit a Comment Cancel replyYour email address will not be published. Required fields are marked *Comment Name *
Email *
Subscribe now for the Newsletter
With the BPW Newsletter we would like to keep you up to date on everything that moves the world of transport, inform you about current projects and innovations and give you insights into our work.
SUBSCRIBE NOW
BPW Bergische Achsen Kommanditgesellschaft
Ohlerhammer
51674 Wiehl
Germany
Phone: +49 2262 78-0
Fax: +49 2262 78-1516
Email: info@bpw.de
Website: www.bpw.de
EMAIL TO THE EDITORS
Do you have feedback, ideas or topic suggestions? Write us!
© 2021 BPW Bergische Achsen Kommanditgesellschaft Ohlerhammer
PRIVACY POLICY
LEGAL NOTICE
TERMS AND CONDITIONS
Designed by Elegant Themes | Powered by WordPress
Send this to a friendSendCancel